How to Replace a Fuel Filter in a Mercury Villager

The fuel filter in your Mercury Villager ensures that the fuel in the fuel injection system stays clean, which prevents plugged fuel injectors or a plugged fuel pressure regulator. Some mechanics recommend changing your fuel filter every 30, 000 to 40, 000 miles. Follow a few directions to replace the fuel filter in your Mercury Villager in less than 45 minutes.

Instructions

Relieve the pressure in the fuel system by first removing the engine compartment relay panel cover on the left side. Then, remove the fuel pump relay from the relay pane and start the engine. Let it idle until it stalls, and then crank the engine for about 5 seconds to make sure the pressure was released. Turn the ignition off.

Disconnect the negative battery cable. Raise and support the Mercury Villager. Remove the fuel hose clamps, and then disconnect and plug the hoses to prevent them from leaking fuel. Take the fuel filter out of the bracket.

Install the new filter in the bracket with the arrow pointing toward the engine, in direction that fuel flows through the system. Connect the fuel hoses to the new filter. Put on the hose clamps and tighten them. Make sure they are properly tightened so there are no fuel leaks, and that pressure is maintained at about 36 in-lbs.

Lower the vehicle and reconnect the negative battery cable. Start the engine of your Mercury Villager, and check for leaks. Make repairs if necessary.

How To Change Your Car's Filters - New Cars, Used Cars, Car ...
www.edmunds.com Car Maintenance How To
Jan 25, 2003 How to Change Your Car's Filters article on Edmunds.com
How to Replace an Air Filter in a Nissan Altima eHow
www.ehow.com Car Maintenance Do It Yourself Car Maintenance
A clean air filter allows air to freely flow to the engine, thus improving gas mileage and increasing engine life. Change the air filter every 3,000 miles when the ...
How to Replace Your Fuel Filter Step 1 - Getting Started
autorepair.about.com/od/regularmaintenance/ss/fuel_filter.htm
What you'll need: new fuel filter new fuel line washers open end wrenches rags eye protection. Your fuel filter is one of those engine components that may only cost $ ...
How to Change the fuel filter on a Ford Escape and most other
diy-auto-repair.wonderhowto.com/how-to/change-fuel-filter-ford...
Changing the fuel filter on your car isn't too hard and is great way to save money for the DIY automotive enthusiast. This video will teach you how to replace the ...
How to Change Your Fuel Filter - YouTube
www.youtube.com/watch?v=S0bWLUA2IQ4
Sign in with your Google Account (YouTube, Google+, Gmail, Orkut, Picasa, or Chrome) to add OrchEnt 's video to your playlist.
How To Install Replace Fuel Gas Tank Ford Mustang Mercury
www.youtube.com/watch?v=AU7SclZpLNU
http://www.1aauto.com/1A/Gas-Tank/For... 1A Auto show you how to install the gas tank on a 1992 Ford Mustang. This procedure is the same for 1983-1997 Ford ...
How do you replace the fuel filter on a Ford Taurus
wiki.answers.com Categories Uncategorized
Answer It is in front of the rear wheel well passenger side, about an inch in. There are two plastic tabs that hold the fuel lines to the filter. Just pop them out ...
How to Change the cabin air filter on Ford Escape, Mercury
diy-auto-repair.wonderhowto.com/how-to/change-cabin-air-filter...
How to Change the cabin air filter on Ford Escape, Mercury Mariner, or Mazda Tribute. Did you know that the Ford Escape, Mercury Mariner, and Mazda Tribute are all ...
How do you replace the fuel filter on a Mercury Sable
wiki.answers.com American Cars Mercury Mercury Sable
Answer It is in front of the rear wheel well passenger side, about an inch in. There are two plastic tabs that hold the fuel lines to the filter. Just pop them out ...
How to Change the Fuel Filter on a Ford Escort eHow
www.ehow.com Car Maintenance Do It Yourself Car Maintenance
The fuel filter on your Ford Escort keeps rust, water, dirt and other contaminants from reaching the engine to prevent serious damage to internal components. However ...
How to Change Your Mercruiser Water Separating Fuel Filter
www.wikihow.com Boats Boat Motors and Marine Engines
How to Change Your Mercruiser Water Separating Fuel Filter. An old fuel filter can slow you down. Replace your fuel filter every season or sooner if needed. Turn off ...
Installing New Fuel Filter Washers - DIY Auto Repair Help - Car ...
autorepair.about.com/od/regularmaintenance/ss/fuel_filter_5.htm
Is it time to replace your fuel filter? Page 5. ... Replace the washers on the fuel filter connections. photo by Matt wright, 2007